Volkswagen ID.4: Loading the roof rack

Maximum permissible roof weight

The maximum permissible roof load is 75 kg (165 lbs).

The roof load consists of the weight of the roof rack and the items carried on the roof rack→ .

Always check the weight of the roof rack and the items that will be transported on it. Weigh the items if necessary.

When using a roof rack with a low load limit, do not load the rack with the maximum permissible roof load. In this case, only load the roof rack to the weight limit listed in the installation guide.

Distributing the load

Distribute the load evenly and secure it correctly → .

Checking that everything is secure

Once you have fitted the roof rack, drive a short distance and then check all the fasteners. Keep checking them regularly → .

WARNING

Accidents, vehicle damage and serious or fatal injuries can result if the maximum permissible roof load is exceeded.

• Never exceed the specified roof load, the Gross Axle Weight Rating, and the Gross Vehicle Weight Rating of the vehicle.
• Do not exceed the load limit of the roof rack, even if the roof load is below the limit.

WARNING

If loose and incorrectly secured luggage falls off the roof rack, accidents and serious or fatal injuries may occur.

• Use only suitable and undamaged tie-downs, fixing and tensioning straps.

NOTICE

If the trunk lid hits the roof load, the vehicle may be damaged.

• Make sure the trunk lid does not run into the roof load when opening the lid.

Introduction

DANGER

The components of the high-voltage system are under high electrical voltage. Contact with live components of the high-voltage system causes burns, serious injuries or fatal electric shock.

• Always assume that the high-voltage battery is fully charged and that all the high-voltage components are live.

  This may be the case even if the ignition is switched off.

• Never touch high-voltage components or orange high-voltage cables. Damage to high-voltage components is not always obvious.
• Never remove the orange high-voltage cables and never damage or modify them.
• Never disconnect the high-voltage cable from the high-voltage system.
• Never open or modify the cover of the high-voltage battery and never remove it.
• Never perform repair and maintenance procedures on orange high-voltage cables or high-voltage components.

  Always have work on the high-voltage system performed by a suitably qualified authorized Volkswagen dealer or authorized Volkswagen Service Facility approved for this work. Volkswagen recommends contacting an authorized Volkswagen dealer or authorized Volkswagen Service Facility.

• Never perform any work in the vicinity of high-voltage components or high-voltage cables using cutting, shaping, or sharp-edged tools or heat sources.

DANGER

Any damage to the vehicle or high-voltage battery may result in the immediate or delayed escape of poisonous gases or liquids. The escaping gases may cause a fire. There is a risk of serious or fatal injuries.

• Do not breathe in gases leaking out of the high-voltage battery.
• Never touch liquids leaking from the high-voltage battery.
• If a fire breaks out, leave the danger zone with all vehicle occupants and contact the fire department.
• Always let the fire service and emergency responders know that your vehicle is equipped with a high-voltage battery.

NOTICE

The high-voltage battery can be damaged by an accident or if the vehicle runs into an obstacle.

• Have your high-voltage battery checked by fully qualified professionals after an accident or if the vehicle runs into an obstacle. Volkswagen recommends contacting an authorized Volkswagen dealer or authorized Volkswagen Service Facility.
• If the high-voltage system has been switched off, secure the vehicle and obtain professional assistance. The vehicle is no longer ready to drive.

Mounting a roof rackWarning signs for the high-voltage system